MVME177-014工控备件模块
（f） 技术人员资格。所有气密性测试必须由一名合格的技术人员进行，该技术人员了解影响测试的变量，并接受制造商或其代表的测试培训。（g） 未经检查的设施。如果出于任何原因，未按照本节的要求进行测试或检查，则业主和操作员必须根据本部分第598.10节的要求使储罐系统的未检查部分停止使用。598.7地面储罐系统——检查。（a） 日常检查。从1995年8月11日开始，业主或操作员必须在每个工作日目视检查地上储罐系统是否泄漏。此外，所有者或操作员必须进行检查，以确保排水阀在未使用时关闭，并且没有未经允许的污水或有害物质排放。（b） 年度检查。（1） 从1995年8月11日开始，用于保护地面储罐底部和连接地下管道的阴极保护系统的结构至电解质电位必须由合格的技术人员每年检查一次。如果系统无法提供必要的保护，则必须根据本部分
（2）节采取措施。（2） 从1996年8月11日开始，业主或运营商必须对地上储罐系统进行全面的年度检查。该检查包括：（i）目视检查裂缝、磨损区域、腐蚀、维护和操作不当、结构过度沉降、储罐保温层分离或膨胀、故障设备、安全联锁、安全跳闸、自动关闭、泄漏检测以及可能无法正常运行的监测、警告或测量设备；（ii）目视检查堤坝和其他二级防护系统是否存在侵蚀、裂缝、泄漏迹象、过度沉降和结构缺陷；（iii）检查外部涂层、防腐系统、外部焊缝和铆钉、基础、泄漏控制设备、应急响应设备和灭火设备的充分性；（iv）目视检查设备、结构和基础是否过度磨损或损坏；和6 NYCRR第598部分–2015年10月11日第16页，共35页598.7（b）（v），审查本部分和本篇第599部分的合规性。（c） 五年检查。（1） 到1999年12月22日，业主或运营商必须检查地上管道系统和所有地上储罐。检验必须符合公认的规范、标准或惯例，并由国家认可的协会或独立测试实验室制定，并符合本分部的规范。根据检查结果，必须对系统密封性、结构稳定性、腐蚀、磨损、基础薄弱性和可操作性进行评估和评估。
(f) Qualification of technicians. All air tightness tests must be carried out by a qualified technician who understands the variables affecting the test and receives test training from the manufacturer or its representative. (g) Uninspected facilities. If, for any reason, a test or inspection is not carried out in accordance with the requirements of this section, the owner and operator must take the uninspected part of the tank system out of service in accordance with the requirements of section 598.10 of this part. 598.7 Surface Tank System - Inspection. (a) Daily inspection. From August 11, 1995, the owner or operator must visually inspect the above ground tank system for leaks every working day. In addition, the owner or operator must check to ensure that the drain valve is closed when not in use and that there is no unauthorized discharge of sewage or harmful substances. (b) Annual inspection. (1) Since August 11, 1995, the structure to electrolyte potential of the cathodic protection system used to protect the bottom of the ground tank and connect the underground pipeline must be checked once a year by qualified technicians. If the system cannot provide the necessary protection, it must be
(2) Section II Measures. (2) From August 11, 1996, the owner or operator must conduct a comprehensive annual inspection of the above ground tank system. This inspection includes: (i) visual inspection of cracks, wear areas, corrosion, improper maintenance and operation, excessive settlement of structures, separation or expansion of tank insulation, faulty equipment, safety interlocks, safety trips, automatic shutdowns, leak detection and monitoring, warning or measuring equipment that may not function properly; (ii) Visually inspect the embankment and other secondary protection systems for signs of erosion, cracks, leakage, excessive settlement and structural defects; (iii) checking the adequacy of external coatings, corrosion protection systems, external welds and rivets, foundations, leakage control equipment, emergency response equipment and fire-fighting equipment; (iv) visual inspection of equipment, structures and foundations for excessive wear or damage; And 6 NYCRR part 598 – October 11, 2015 page 16 of 35 598.7 (b) (v), reviewing compliance with this part and part 599 of this title. (c) Five year inspection. (1) By December 22, 1999, the owner or operator must inspect the above ground piping system and all above ground tanks. The inspection must conform to recognized codes, standards or practices, be formulated by a nationally recognized association or independent testing laboratory, and conform to the specifications of the Division. Based on the inspection results, the system tightness, structural stability, corrosion, wear, foundation weakness and operability must be evaluated and evaluated.
