PFTL101BE 20.0KN电源模块
•封闭周界和危险区域之间的整个地面区域必须由垫子传感器覆盖,以便人员在不启动垫子系统的情况下无法进入封闭区域。危险压力敏感垫固定防护联锁门(带锁)9第4节-规范控制单元440F-C4000P 440F-C400S 440F-C4000 D符合EN 1760-1、EN 60204-1、EN 954-1:3类,UL 508响应时间(垫子按压-35mS安全触点打开)环境保护IP65 NEMA12外壳-IP40 DIN0470端子-IP20 DIN0470脉冲耐受电压2500V污染等级III最小开关电流/电压10mA/10V电源-用户选择110/230V AC(50-60Hz)和24V AC/DC+10%-15%(110V设置也允许在100v±10%下使用)功耗<9 VA 6W继电器输出2个独立的无电压N/O安全触点1个无电压N/C辅助触点NB-Aux不得用于外部安全电路保险丝,AC最大5A(快速作用),AC最大2.5A(快速作用的),DC使用类别AC-15;4A/250V交流-直流-13;2A/30V DC输出:远程复位/指示灯24V DC/0.24W输入远程复位开关(2 x N/O)安全输入4线垫指示灯LED 1电源绿色LED 2自动复位模式绿色LED 3手动复位模式绿色LED4机器启用绿色内部控制交流电压选择器,自动/手动复位选择器内部电源保险丝500mA可更换500mA可替换500mA可换(2个)(2个关闭)(1个关闭)500mA可重置(1个)工作温度范围-10°C至+45°C湿度在+50°C时敢达90%RH根据IEC 68-2-6进行振动测试,频率范围10-55Hz,每轴位移0.15mm 10个周期,扫描速率,每分钟1倍频程MC-MC接触器监控回路常闭接触器回路最大导线尺寸为1 x 1.5mm2绞合1 x 1.5mmm2绞合2 x 1.5mm2,套管剥离,套管剥离5mm,1 x 2.5mm2 5mm,1×2.5mm2 8mm,2 x 2.5mm2实心导体实心导体实心导线端子负端子负端子正/负外加螺钉M2.5螺钉M2.5端子螺钉M3.5安装在45°处,安装在45度处,可自行提升至PCB至PCB连接,根据VDE 0110材料,可单独拆卸的垫圈端子板安装组C,聚碳酸酯钢,带聚碳酸酯聚碳酸酯屏幕固定细节4 x M4孔4 x M6孔35mm,导轨其他。在手动复位N/A N/A模式(M)下,必须连接复位按钮外壳D=75mm D=143mm D=120mm H=180mm H=230mm H=73mm W=130mm W=210mm W=152mm 32路导轨重量880g 3200g 920g 10传感器垫传感器垫符合EN 1760-1,EN954-1:类别1,UL 508有保证检测的人的最小重量:35Kg最大检测区域:100m2单个垫的最大数量:无限制(最多100m2)连接线的最大总长度:200m质量/m2(传感器垫):24Kg环境保护垫:IP67机械寿命:1 x 106操作湿度:0-100%RH传感器垫外层材料:乙烯基标准颜色:黄色工作温度范围-10°C至+55°C存储温度范围-40°C至+70°C
• The entire floor area between the enclosed perimeter and the hazard must be covered by mat sensors so that it is not possible for personnel to be in the enclosed area without actuating the mat system. HAZARD PRESSURE SENSITIVE MATS FIXED GUARDING INTERLOCKED DOOR (WITH LOCKING) 9 Section 4 - SPECIFICATIONS Control Unit 440F-C4000P 440F-C4000S 440F-C4000D Conformity EN 1760-1, EN 60204-1, EN 954-1: CATEGORY 3, UL 508 Response time (mat pressed- 35mS safety contacts open) Environmental protection IP65 NEMA12 Enclosure-IP40 DIN0470 Terminals-IP20 DIN0470 Impulse withstand voltage 2500V Contamination level III Min switched current/voltage 10mA/10V Power supply - user select 110/230V AC (50-60Hz) and 24V AC/DC +10% -15% (110V setting also allows use at 100v ±10%) Power consumption <9 VA 6W Relay outputs 2 x independant volt free N/O safety contacts 1 x volt free N/C auxilliary contact NB - Aux must not be used for safety circuit Fuse externally, 5A max (quick acting) for AC 2.5A max (quick acting) for DC Utilisation category AC - 15 ; 4A / 250V AC DC - 13 ; 2A / 30V DC Outputs: remote reset/indicator 24V DC / 0.24W Inputs Remote reset switch (2 x N/O) Safety inputs 4 wire mat Indicator LEDs LED 1 Power GREEN LED 2 Auto reset mode GREEN LED 3 Manual reset mode GREEN LED 4 Machine enabled GREEN Internal controls AC Voltage selector, auto/manual reset selector Internal supply fuses 500mA Replaceable 500mA Replaceable 500mA Replaceable (2 off) (2 off) (1 off) 500mA Resettable (1 off) Operating temperature range -10°C to +45°C Humidity Up to 90% RH at +50°C Vibration Tested in accordance with IEC 68-2-6, frequency range 10 - 55Hz, displacement 0.15mm 10 cycles per axis, sweep rate, 1 octave per minute MC-MC Contactor monitor loop Normally closed contactor loop Maximum conductor size 1 x 1.5mm2 stranded 1 x 1.5mm2 stranded 2 x 1.5mm2 stranded with sleeves stripped with sleeves stripped with sleeves stripped 5mm, 1 x 2.5mm2 5mm, 1 x 2.5mm2 8mm, 2 x 2.5mm2 solid conductor solid conductor solid conductor Terminals Minus terminal Minus terminal Plus/minus captive screws M2.5 screws M2.5 terminal screws M3.5 mounted at 45° mounted at 45° with self lifting to PCB to PCB connection,washer terminal boards separately removable Installation group C in accordace with VDE 0110 Material Polycarbonate Steel c/w Polycarbonate polycarbonate screen Fixing details 4 x M4 holes 4 x M6 holes 35mm din-rail Misc. In the manual reset N/A N/A mode (M), a reset button must be connected Housing D = 75mm D = 143mm D = 120mm H = 180mm H = 230mm H = 73mm W = 130mm W = 210mm W = 152mm 32 way din-rail Weight 880g 3,200g 920g 10 SENSOR MAT Sensor mat conformity: EN 1760-1, EN954 -1: CATEGORY 1, UL 508 Minimum weight of person with assured detection: 35Kg Maximum detection zone: 100m2 Maximum number of individual mats: No limit (up to max 100m2) Maximum total length of connection wires: 200m Mass / m2 (sensor mats): 24Kg Environmental protection mats: IP67 Mechanical life: 1 x 106 operations Humidity: 0 - 100% RH Sensor mat outer covering material: Vinyl Standard colour: Yellow Operating temperature range -10°C to + 55°C Storage temperature range -40°C to +70°C